Opel Astra
+ Cars Opel Astra and Zafira
+ The operation manual
+ Routine maintenance
+ The engine
+ Systems of cooling, heating
+ The power supply system and release
+ Engine electric equipment
- Manual transmission
Specifications
Adjustment of a drive of a gear change
Removal and installation of the mechanism of a gear change
Replacement of epiploons
Check of serviceability of functioning, removal and installation of the gauge-switch of fires of a backing
Removal and installation of the gauge of speed (VSS)
Replacement трансмиссионного oils
Removal and installation manual transmission
Repair manual transmission - the general information
+ Automatic transmission
+ Coupling and power shafts
+ Brake system
+ Suspension bracket and steering
+ Body
+ Onboard electric equipment
|
Replacement трансмиссионного oils
|
|
On transmissions F13, F17 and F18: replacement of a lining of the bottom cover of differential is required. |
|
|
- Make on the car a short trip for the purpose of warming up manual transmission to normal working temperature.
|
|
At procedure performance be careful, - try not to burn about hot surfaces of the power unit. |
- Switch off ignition, cock a lay brake, поддомкратьте redock of the car and establish it on props. At a corresponding complete set remove protection картера.
|
|
Transmissions F13, F17 and F18
|
|
- Carter of transmissions of the given type is not equipped by a drain stopper. In case of need опорожнение boxes can be made in the unique way, - by removal of the bottom cover of differential.
- Wipe a cover of differential and a surface картера round it pure rags. Get under transmission suitable drain capacity.
|
-
In stages in regular intervals release fixing bolts, uncover and allow to oil to flow down in the prepared capacity. The sealing lining of a cover is subject to replacement without fail.
|
|
- After вытекание oils will stop, wipe interfaced surfaces of a cover and the differential case, and also an internal surface of a cover.
- Establish a new lining and press a cover to differential. Screw fixing bolts and, moving to a diagonal order, in stages in regular intervals tighten them with demanded effort. Lower the car on the earth.
- Make transmission refuelling by fresh oil, its gulf through an aperture under installation of the gauge-switch of fires of a backing, - preliminary disconnect electroconducting and remove the gauge (Check of serviceability of functioning, removal and installation of the gauge-switch of fires of a backing see). Having filled in necessary quantity of oil of a demanded grade, establish into place the gauge-switch and tighten it with demanded effort.
|
|
Transmission F23
|
|
- Wipe a place round a drain stopper and get under transmission drain capacity of suitable volume.
- Turn out a stopper.
- Wait end вытекания oils, then establish a stopper into place and tighten it with demanded effort (do not forget to replace a sealing ring if that is provided). Lower the car on the earth.
|
- Transmission refuelling is made through the jellied aperture equipped with a stopper in the top part картера transmissions. In summary screw a stopper and tighten it with demanded effort (at a corresponding complete set do not forget to replace a sealing ring).
|
|
|
All transmissions
|
|
- Make on the car a short trip for the purpose of oil distribution on internal components manual transmission.
- In summary park the car on an equal horizontal platform and check up level трансмиссионного oils (Routine maintenance see the Head).
|
|
|
|